Product ID:21216 ALKYD TRAFFIC PAINT - YELLOW
MSDS Date:08/26/1992
FSC:8010
NIIN:00F046835
MSDS Number: BYNPS

GLIDDEN COMPANY

925 EUCLID AVENUE
CLEVELAND, OH 44115-5000
US

Emergency Phone: 800-634-0015/216-344-8049

Info Phone: 216-344-8000/800-634-0015

Cage: 01PD6

GLIDDEN PAINT, ICI PAINTS NORTH AMERICA

CLEVELAND, OH 44115 US

Telephone: 800-545-2643/216-344-8207

Cage: 01PD6

LIGHT ALIPHATIC NAPHTHA, VM & P NAPHTHA, LACOLENE

CAS: 64742-89-8

Fraction By Weight: 10-20%

OSHA PEL 300 PPM

ACGIH TLV: 300 PPM

CALCIUM CARBONATE, DOMOLITE, LIMESTONE, WHITING *96-1*

CAS: 1317-65-3

RTECS: EV9580000

Fraction By Weight: 10-20%

ACGIH TLV: 10 MG/CUM (DUST)

GROG; CALCIUM-BARIUM PHOSPHOSILICATE, ALUMINUM SILICATE

CAS: 66402-68-4

Fraction By Weight: 5-10%

TOLUENE (IARC CARC- GROUP 3) *96-1*

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 5-10%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

BENZENE (SUSPECTED HUMAN CARC BY ACGIH, IARC, ANIMAL

CAS: 71-43-2

RTECS: CY1400000

Fraction By Weight: 0.01-1%

ACGIH TLV: 0.3 MG/CUM (A2) IC

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

SILICON DIOXIDE, CRYSTALLINE QUARTZ, SAND (ANIMAL CARC,

CAS: 14808-60-7

RTECS: VV7330000

Fraction By Weight: 10-20%

OSHA PEL 0.1 MG/CUM RESP DUST

ACGIH TLV: 0.1 MG/CUM RESP DUST

LEAD CHROMATE, CR, CHROME GREEN, CHROME YELLOW (SUSP HUMAN

CAS: 7758-97-6

RTECS: GB2975000

Fraction By Weight: 0.1-1%

OSHA PEL 0.5 MG/CUM PB

ACGIH TLV: 0.05 MG/CUM CR (A2)

LEAD, INORGANIC LEAD (IARC CARC GROUP 2B) *96-1*

CAS: 7439-92-1

RTECS: OF7525000

Fraction By Weight: 1-5%

ACGIH TLV: 0.15 MG/CUM

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

LEAD (II) SULFATE

CAS: 7446-14-2

RTECS: OG4375000

Fraction By Weight: 1-5%

OSHA PEL 0.05 MG(PB)/CUM

ACGIH TLV: 0.15 MG(PB)/CUM

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

LD50 LC50 Mixture:ORAL LD50(RAT): 636 MG/KG TOLUENE
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: CNS DEPRESSION, ANESTHETIC
EFFECT, IRRITATION OF RESPIRATORY TRACT/MUCOUS MEMBRANES,
RESPIRATORY FAILURE, ASPHYXIATION, DEATH. SKIN: DERMATITIS,
IRRITATION & SENSITIZATION, MAY BE ABSORBED . EYES: SEVERE
IRRITATION & CORNEAL INJURY. INGESTION: ASPIRATION INTO LUNGS
CAUSES DAMAGE, CNS DEPRESSION. (SEE SUPP)
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:FATIGUE, DROWSINESS, DIZZINESS,
LIGHTHEADEDNESS, HEADACHE, UNCOORDINATION, NAUSEA, COUGHING,
INTOXICATION, CONFUSION, BREATHING DIFFICULTY, DEFATTING, BLURRED
VISION, TEARING, REDNESS, VOMITING, DIARR HEA, GI DISTURBANCES,
NARCOSIS. LEAD-FATIGUE, SLEEP DISTURBANCE, CONSTIPATION, COLIC,
ANEMIA, NEURITIS, ANXIETY, PALLOR.
Medical Cond Aggravated by Exposure:RESPIRATORY ILLNESS, DERMATITIS,
ECZEMA, EYES, SKIN, RESPIRATORY DISORDERS, CARDIAC ABNORMALITIES,
KIDNEY/LIVER DISORDERS.

First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE & SUPPORT BREATHING.
TRAINED PERSON MAY GIVE OXYGEN IF NEEDED. SKIN: FLUSH W/WATER. THEN
WASH THOROUGHLY W/SOAP & WATER. EYES: FLUSH IMMEDIATELY W/LARGE
AMOUNT S OF WATER FOR 15 MINS. OBTAIN MEDICAL ATTENTION IN ALL
CASES.

Flash Point Method:SCC
Flash Point:25F
Lower Limits:1.3
Upper Limits:7
Extinguishing Media:SAND/GROUND LIMESTONE, WATER FOG/FOAM.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING, EYE PROTECTION
& SCBA.
Unusual Fire/Explosion Hazard:FINE ORGANIC PARTICULATES & AIR ARE
EXPLOSIVE MIXTURE. VAPORS TRAVEL TO DISTANT IGNITION SOURCES &
FLASHBACK, IGNITE EXPLOSIVELY AT AMBIENT TEMP. (SEE SUPP)

Spill Release Procedures:REMOVE IGNITION SOURCES. PREVENT FORMATION OF
AIRBORNE PARTICLES. CLEAN/REMOVE W/EXPLOSION-PROOF VACUUM CLEANER
EQUIPPED W/HIGH EFFICIENCY FILTER. VENTILATE AREA W/EXPLOSION-PROOF
EQUIPMENT. USE NON-S PARKING TOOLS. LARGE: DIKE & CONTAIN. (SEE
SUPP)

Handling and Storage Precautions:TO MAXIMIZE SHELF LIFE STORE <80F.
KEEP FROM HEAT, SPARKS & OPEN FLAME. USE ONLY W/ADEQUATE
VENTILATION.
Other Precautions:KEEP TIGHTLY CLOSED & UPRIGHT WHEN NOT IN USE. DON'T
TAKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN. AVOID SKIN/EYES &
BREATHING OF VAPORS. DRIED FILM OF THIS PRODUCT MAY BE HARMFUL IF
EATEN/CHEWED. D ON'T APPLY ON EXTERIOR SURFACES.

Respiratory Protection:USE ONLY NIOSH/MSHA APPROVED RESPIRATORS.
Ventilation:DILUTION VENTILATION/LOCAL EXHAUST. USE EXPLOSION-PROOF &
NON-SPARKING EQUIPMENT.
Protective Gloves:IMPERVIOUS
Eye Protection:SAFETY GLASSES/GOGGLES
Other Protective Equipment:EYE WASH, SAFETY SHOWER.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING/BEFORE EATING/SMOKING.
Supplemental Safety and Health
UNUSUAL FIRE: CLOSED CONTAINERS EXPLODE IF EXPOSED TO EXTREME
HEAT/FIRE. HEALTH HAZARDS: LEAD-LEAD POISONING, SEVERE DAMAGE TO
RED BLOOD CELL FORMATION/KIDNEYS/NERVOUS & REPRODUCTIVE SYSTEMS.
SPILLS: SAFELY STOP LEAK. PUMP TO STORAGE/SALVAGE VESSELS. PICKUP
EXCESS RESIDUE W/ABSORBENT MATERIAL. KEEP OUT OF SEWERS.

Boiling Pt:B.P. Text:200-250F
Spec Gravity:1.477
Appearance and Odor:YELLOW LIQUID
Percent Volatiles by Volume:50

Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS, BASES, AMINES.
Stability Condition to Avoid:ELEVATED TEMP, TEMP >DECOMPOSITION RANGE,
HEAT, SPARKS, OPEN FLAMES.
Hazardous Decomposition Products:CO, CO2, MISCELLANEOUS AROMATIC &
ALIPHATIC HYDROCARBONS.

Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS. FLAMMABLE LIQUID,
UN1263.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.